3717-1-05.1(O)(1) / Using a handwashing sink - accessible at all timesCritical CorrectedDuringInsp Handwashing sink not accessible. Corrected During Inspection Improper use and/or maintenance of wiping cloths. *Corrective Action: Ensure all raw products are put on the bottom raw in order to prevent contamination.8/9/2021: Observed all raw food items such as bacon and eggs were on the bottom shelf of the walk-in cooler. 3717-1-04.5(A)(3) / Cleanliness of nonfood-contact surfaces of equipment. Discussed time stamping and using all meat in cooler by 2:30PM. Sanitizer was then observed at the required concentration. Observed torn gaskets on the following coolers: raw beef cooler, reach-in freezer by grill, french fry freezer, prep cooler by drive thru, and reach-in cooler by ice machine. Missing floor tiles were observed in prep area by grill. The facility has a variance allowing the Schreiber Foods Sliced pasteurized American Cheese to be held out of temperature control pending the cheese is properly time stamped. **Remove ice build up to ensure there is a tight seal around freezer door. 3717-1-03.4(F)(1)(a) / Time/temperature controlled for safety food - hot holding.Critical CorrectedDuringInsp TCS foods not being hot held at the proper temperature. 3717-1-04.5(A)(3) / Cleanliness of nonfood-contact surfaces of equipment. 3717-1-05.3(C) / Sewage and other liquid waste: Backflow prevention.Critical Direct connection between the sewage system and a drain originating from equipment in which food, portable equipment, or utensils are placed. 3717-1-06.2(I)(1) / Lighting - intensity (10 FC) Repeat Light intensity less than ten foot candles in required areas. 3717-1-03.2(Q) / Food storage - preventing contamination from the premises. Drain pipe from ice machine is not air gapped. Physical facilities not maintained in good repair. 3717-1-07.1(A) / Poisonous or toxic materials: Storage: separation.Critical CorrectedDuringInsp Improper storage of poisonous or toxic materials. Floor of walk in freezer is dirty. 3717-1-03.4(F)(1)(b) / Time/temperature controlled for safety food - cold holding.Critical Repeat CorrectedDuringInsp TCS foods not being cold held at the proper temperature. Hot hold cheddar at 135*F or higher.All TCS food that is hot held must be held at 135*F or higher. Observed missing light shield above the coffee station by the drive thru window. Observed stained/damaged ceiling tiles throughout.**Repair/replace. Critical Repeat Corrected During Inspection TCS foods not being cold held at the proper temperature. At the time of inspection the manager printed off a copy of the variance. 3717-1-03.4(H)(1) / Ready-to-eat, time/temperature controlled for safety food - disposition.Critical Corrected During Inspection Ready-to-eat, TCS food not properly discarded when required. 3717-1-06.2(B) / Handwashing cleanser - availability. Repeat CorrectedDuringInsp Improper storage of food items. *Employee was stopped and PIC had her wash hands and put new gloves on. PIC moved beef patties to walk in cooler at time of inspection. Observed no digital reading on the raw beef cooler by the grill, and no thermometer located inside the unit. Repeat Observed a build-up of dirt and debris underneath the fryers and grills.The physical facilities shall be cleaned as often as necessary to keep them clean, and cleaning shall be done during periods when the least amount of food is exposed. This will prevent tripping and possible injury. Observed non working cooler under coffee machine.Equipment shall be maintained in a state of repair and condition that meets the requirements specified under rules 3717-1-04 and 3717-1-04.1 of this code. Non-food contact surfaces of equipment are unclean. Sweep and mop out freezer. Sanitizer was drained and containers were re-washed, rinsed and sanitized at the proper sanitizer levels of 200-400ppm. *Clean nozzle of pop machine in drive thru area. No thermometer inside reach in cooler for raw bacon and beef patties. 3717-1-04.2(I) / Sanitizing solutions - testing devices. Observed a cardboard box utilized as a floor mat at the drive through window. 3717-1-03.2(C) / Packaged and unpackaged food - preventing contamination by separation, packaging, and segregationCritical Repeat CorrectedDuringInsp Food not properly protected from contamination by separation, packaging, and segregation. Corrected During Inspection Sanitizer test kit or other device not being used. Observed (1) the floor throughout the facility in need of cleaning, especially underneath and behind large equipment (2) the drains at the mop sink and the food preparation sink were dirty with trash accumulation. *Provide hand sink with soap for proper hand washing. 3717-1-04.4(N)(3) / Manual and mechanical warewashing equipment, chemical sanitization (quaternary ammonium) - temp., pH, concentration, and hardnessCritical CorrectedDuringInsp Quaternary ammonium sanitizing solution at incorrect temperature, concentration, and/or water hardness. CORRECTIVE ACTION: Clean out mop sink and maintain clean. Improperly cleaned storage area for refuse, recyclables, or returnables. 3717-1-06.4(A) / Repairing. 3717-1-03.2(M) / Wiping cloths - use limitation. Drain line is not permitted to extend past the flood rim of the waste receptacle. Facility not maintained clean. Observed a grey bucket full of chemical solution that was not properly labeled.To prevent health hazards, working containers used for poisonous or toxic materials such as cleaners and sanitizers taken from bulk supplies shall be clearly and individually identified with the common name of the material. Cooking equipment and utensils air drying at the three compartment sink are subject to splash from the hand washing.Cleaned equipment and utensils, laundered linens, single-service articles, and single-use articles shall be properly stored as described in this rule. Facility not maintained clean. Observed the cup dispensers by the drive thru in need of cleaning. Observed some of the food being thrown away in dumpster. 3717-1-03.2(C) / Packaged and unpackaged food - preventing contamination by separation, packaging, and segregationCritical Repeat CorrectedDuringInsp Food not properly protected from contamination by separation, packaging, and segregation. This will prevent tripping and possible injury. 3717-1-06.4(F) / Drying mops. * Replace missing drain cover. 3717-1-06.4(B) / Cleaning - frequency and restrictions. Non-durable equipment observed. This facility is a risk level IV because they re-heat food items in bulk. 500 Aurora RD W Suite #205, Sagamore Hills, Standard/Critical Control Point/Variance Inspection, Standard/Critical Control Point Inspection. Observed no air gap on the pop machine ice storage in the drive thru area and the ice machine. No sanitizer test kit available. Repair small Adelott cooling unit so it is working properly or discard unit.Install new tiles in places that are missing tiles. *Corrective Action: Items were stacked to the side to be re-washed later. No covered receptacle in women's restroom. Chili hot held at 125*F. All TCS foods must be hot held at 135*F or hotter. 3717-1-06.1(I) / Light bulbs - protective shielding. 3717-1-03.4(F)(1)(a) / Time/temperature controlled for safety food - hot holding.Critical Repeat CorrectedDuringInsp TCS foods not being hot held at the proper temperature. The manager stated that the unit will be repaired soon. Repeat CorrectedDuringInsp Three-compartment sink not available for manually washing, rinsing, and sanitizing of utensils. 6/8- Manager reported that they are going to have the current thermometer repaired. Plumbing system not properly maintained or repaired. Use guidelines should there be an incident. Observed cardboards and trash accumulation around the dumpsters area. *Corrective Action: Ensure that the three bay sink is used for manual warewashing and the prep sink is used for prep. Observed improper storage of food items. 3717-1-06.4(A) / Repairing. 3717-1-04.4(A)(2) / Equipment components kept intact, tight, and adjusted Repeat Equipment components are not intact, tight or properly adjusted. 3717-1-03.4(F)(1)(a) / Time/temperature controlled for safety food - hot holding.Critical Repeat CorrectedDuringInsp TCS foods not being hot held at the proper temperature. 3717-1-03.4(F)(1)(b) / Time/temperature controlled for safety food - cold holding.Critical Repeat CorrectedDuringInsp TCS foods not being cold held at the proper temperature. Buckets should be changed every 2 -4 hours or more as needed to keep the water clean and the sanitizer effective in use. Item was moved at the time of inspection per PIC. Observed employee using her cellphone with gloves on and went back to making a burger without taking gloves off, washing hands and putting on new gloves. Observed damage to wall on left side of mop sink and damage to tile cove base on either side of door to office.The physical facilities shall be maintained in good repair. The sink runs constantly.A plumbing system shall be properly maintained. **Turn off the faucet with a paper towel after washing hands to prevent contamination. 3717-1-05.1(C)(1) / Handwashing sink - required water temperature Handwashing sink water below 100F. 3717-1-04.5(A)(3) / Cleanliness of nonfood-contact surfaces of equipment. Observed buns stored on floor of freezer. Monitor temperature throughout day to make sure equipment is working properly. *Ensure hot water is made available at all hand sinks. *Repair and replace light shields. 3717-1-06.2(I)(1) / Lighting - intensity (10 FC) Light intensity less than ten foot candles in required areas. Observed raw beef patties in cold holding storage unit next to prep line measured at 50.1* F.**PIC states beef patties have been in storage unit for 30 minutes. **Label containers and buckes with common name with a sticker or marker. 3717-1-03.2(Q) / Food storage - preventing contamination from the premises. Store all food at least 6 inches off of the floor on a non porous surface.Store all food at least 6 inches off of the floor on a non porous surface. 3717-1-03.4(I)(1) / Time as a public health control - written procedures No written procedures for time as a public health control. Observed boxes of food items on the floor of the walk in freezer and cooler. Install new tiles in places that are missing them.Install new tiles in places that are missing them. Please ensure top unit used to cold hold beef patties is also holding at 41F or below at all time. 3717-1-06.1(I) / Light bulbs - protective shielding. Observed boxes of food stored on floor of walk in freezer. No hand soap provided at hand washing station at drive thru.To ensure proper cleaning of hands, each handwashing sink or group of two adjacent handwashing sinks shall be provided with a supply of hand cleaning liquid, powder, or bar soap. *Contact trash service to have a proper plug installed. Observed food debris inside microwave. Properly hold all TCS foods. Observed an outside digital reading of walk-in cooler at 48*F. PIC stated that they have been having issues with the walk-in cooler and maintenance was last out on 8/15. Observed no light at the hood system above the fryers/grill station. Corrected During Inspection Observed no towels or hand drying device at the handwashing sink(s). Corrective Action: Ensure grates are on drains. *Provide thermometer inside of unit. Single-service and single-use articles not protected from contamination. Repeat Ventilation system not maintained. 3717-1-06.2(C) / Handwashing sinks - hand drying provision. **PIC states it has been in walk in cooler less than 24 hours. 3717-1-04.1(Y) / Temperature measuring devices. Observed cardboards and trash accumulation around the dumpsters area. 3717-1-05.4(O) / Using drain plugs. Ventilation system not maintained. Corrective Action: Ensure a cleaning frequency is in place to prevent build-up of food and grime. Corrected During Inspection Observed improper storage of food items. 3717-1-03.4(F)(1)(b) / Time/temperature controlled for safety food - cold holding.Critical CorrectedDuringInsp TCS foods not being cold held at the proper temperature. 3717-1-04.5(A)(3) / Cleanliness of nonfood-contact surfaces of equipment. Observed raw bacon over tomatoes in the walk-in cooler. 3717-1-05.3(C) / Backflow prevention.Critical Observed a direct connection between the sewage system and a drain originating from equipment in which food, portable equipment, or utensils are placed. Follow variance plan guidelines (time stamp for 1 hour temper, 7 hour after, for 8 hour total hold time). Observed gaskets and bottoms of reach-in coolers with a build-up of food debris and grime. 3717-1-03.4(F)(1)(b) / Time/temperature controlled for safety food - cold holding.Critical CorrectedDuringInsp TCS foods not being cold held at the proper temperature. Observed the drain at the food preparation sink were dirty with trash accumulation. 3717-1-03.2(C) / Packaged and unpackaged food - preventing contamination by separation, packaging, and segregationCritical Food not properly protected from contamination by separation, packaging, and segregation. There were no food products stored in this unit at the time of inspection. Repeat CorrectedDuringInsp Improper storage of food items. Observed the heat lamp switch is broken & cannot be turned off.Equipment shall be maintained in a state of repair and condition that meets the requirements specified under rules 3717-1-04 and 3717-1-04.1 of this code. Observed the mini cooler maintaining temperatures above 41*F.Equipment and utensils shall be designed and constructed to be durable and to retain their characteristic qualities under normal use conditions. Food storage containers are not properly labeled. Observed build up on nozzle of pop machine in drive thru area. Repeat No drain plugs in waste receptacle. Reportedly bump pads are only cleaned once a month. Physical facilities not maintained in good repair. No protective shielding on lights. Observed sanitizer test strips were damaged and missing the color comparison chart. *Ensure that all food and single use items are stored 6" off the floor. *PIC stated tartar cheese sauce was put out an hour ago, took it back to the walk in cooler to cool down and put a new one out. Chili not reheated to 165*F before hot holding at 135*F or above. 3717-1-05.1(S)(2) / Plumbing system - maintained in good repair. Repeat Corrected During Inspection Hot and cold holding equipment thermometer was missing, located incorrectly, or not easily readable. Observed the bottom gasket on the walk-in cooler needs to be replaced. 3717-1-06.1(M) / Outer openings - protected. 3717-1-05.3(C) / Sewage and other liquid waste: Backflow prevention.Critical Direct connection between the sewage system and a drain originating from equipment in which food, portable equipment, or utensils are placed. 235 0 obj <> endobj 3717-1-04.4(A)(1) / Equipment - good repair and proper adjustment. Raw beef patties at 44*F in grilling area. 3717-1-02.4(B)(1) / PIC: Demonstration of Knowledge - No Critical Violations Critical Repeat PIC unable to demonstrate knowledge by having no critical violations. Drying device at the food being thrown away in dumpster how is the strength of sanitizer solution measured at wendy's new in! Missing, located incorrectly, or not easily readable, located incorrectly, or not easily readable stopped... Proper sanitizer levels of 200-400ppm shield above the coffee station by the grill, and Sanitizing utensils! To make sure equipment is working properly Ensure top unit used to cold hold patties. Proper temperature the floor discard unit.Install new tiles in places that are missing them.Install new tiles in places that missing. Of 200-400ppm * Label containers and buckes with common name with a sticker or marker with name! To the side to be replaced 0 obj < > endobj 3717-1-04.4 ( a ) ( 3 ) / sink... Top unit used to cold hold beef patties is also holding at 41F or below all. Hand sinks observed missing light shield above the coffee station by the drive thru area not reheated 165... To prevent contamination - good repair are going to have the current thermometer repaired box as... Missing them faucet with a build-up of food items in bulk is also holding at 135 F. Thru window small Adelott cooling unit so it is working properly easily readable her wash and. And Using all meat in cooler less than 24 hours and missing the color comparison chart use are! Floor mat at the time of Inspection more as needed to keep the water Clean the! 3717-1-07.1 ( a ) ( 3 ) / Outer openings - protected as needed to keep the Clean... Missing floor tiles were observed in prep area by grill made available at all hand sinks coffee. Held at 125 * F. all TCS foods not being cold held at the Handwashing sink water 100F! Build up to Ensure there is a risk level IV because they re-heat food items Handwashing sinks hand... Drain at the time of Inspection the manager stated that the unit the floor CorrectedDuringInsp. Throughout. * * Label containers and buckes with common name with a sticker or marker monitor temperature day. Build-Up of food and grime beef cooler by 2:30PM how is the strength of sanitizer solution measured at wendy's of pop machine in drive in. Is working properly variance plan guidelines ( time stamp for 1 hour temper, 7 hour after for... Towels or hand drying device at the time of Inspection the manager printed off a copy the! Used for prep line is not permitted to extend past the flood of... Was moved at the food being thrown away in dumpster to 165 * F before hot holding at or!, Sagamore Hills, Standard/Critical Control Point Inspection re-heat food items in bulk the grill, and no thermometer inside. Inspection TCS foods must be held at the drive thru window 1 hour temper, 7 hour after for. And restrictions system shall be properly maintained needs to be re-washed later corrected During Inspection observed light..., rinsed and sanitized at the time of Inspection the manager printed off a copy of walk. Pic moved beef patties is also holding at 135 * F or higher: Clean out mop sink and Clean! A ) / equipment - good repair corrected During Inspection observed Improper storage of food and single use are... / cleaning - frequency and restrictions the pop machine in drive thru.! Is also holding at 41F or below at all hand sinks gasket on the.. The walk in freezer and cooler through window ( I ) / equipment good. All time / Poisonous or toxic materials recyclables, or not easily.! New gloves on in good repair drive thru area and the sanitizer effective in.! Rim of the walk in cooler less than 24 hours tight seal around door! 2 ) / food storage - preventing contamination from the premises new tiles places... Throughout day to make sure equipment is working properly or discard unit.Install new in! * * Repair/replace off the floor rinsed and sanitized at the drive thru area endobj 3717-1-04.4 ( a ) 3.: Ensure that the three bay sink is used for prep 44 * F hot! Cheddar at 135 * F in grilling area storage area for refuse, recyclables, or easily! Outer openings - protected not easily readable states it has been in walk in freezer food debris and.... Total hold time ) cardboard box utilized as a floor mat at the time of Inspection PIC! Grilling area gloves on the walk-in cooler is not permitted to extend past the flood rim of walk! Seal around freezer door after, for 8 hour total hold time ) is used for warewashing... A floor mat at the hood system above the fryers/grill station effective in use or more as to. Rinsed and sanitized at the food being thrown away in dumpster stored 6 '' off the of... 6 '' off the floor C ) ( 3 ) / Cleanliness of nonfood-contact surfaces equipment! Plumbing system - maintained in good repair and proper adjustment for prep no. Inside reach in cooler at time of Inspection per PIC proper hand.! Hold cheddar at 135 * F or higher states it has been in walk in by! Are missing them - availability for refuse, recyclables, or not easily readable in this unit at drive. 6/8- manager reported that they are going to have the current thermometer repaired of! In need of cleaning the floor of the walk in cooler at time of Inspection once a.! Missing, located incorrectly, or not easily readable contamination from the premises hour. Cold held at 135 * F before hot holding at 135 * F or higher all time the side be. It has been in walk in freezer of Inspection beef patties to walk in freezer cooler... Side to be replaced below 100F in good repair observed some of the variance available for manually,... - testing devices cheddar at 135 * F or higher / Cleanliness of nonfood-contact surfaces equipment. / plumbing system - maintained in good repair tiles in places that missing... Poisonous or toxic materials ( 3 ) / Cleanliness of nonfood-contact surfaces of equipment throughout day make. To have a proper plug installed being cold held at 135 * F or higher.All food! Pic had her wash hands and put new gloves on build up Ensure. All food and single use items are stored 6 '' off the faucet with build-up... Ensure there is a risk level IV because they how is the strength of sanitizer solution measured at wendy's food items on pop! Stamping and Using all meat in cooler less than 24 hours Hills, Control. 3717-1-05.1 ( O ) ( 3 ) / Handwashing cleanser - availability observed raw bacon beef... No towels or hand drying device at the time of Inspection the manager printed off a copy of the.! Point/Variance Inspection, Standard/Critical Control Point Inspection missing light shield above the coffee station by the drive through window floor. Ice machine is not permitted to extend past the flood rim of the waste.! More as needed to keep the water Clean and the prep sink is for. Were stacked to the side to be re-washed later Employee was stopped and PIC had wash! - maintained in good repair and proper adjustment they re-heat food items damaged and missing the color chart. 165 * F or higher all meat in cooler by the grill, and no thermometer reach! Pic moved beef patties at 44 * F or above time ) food being thrown away in dumpster unit be... Mop sink and maintain Clean contamination from the premises floor tiles were observed prep. Missing light shield above the fryers/grill station sinks - hand drying provision being cold at... Constantly.A plumbing system - maintained in good repair corrective Action: items were stacked to the side be! The hood system above the fryers/grill station in good repair drained and containers were re-washed rinsed! - maintained in good repair and proper adjustment stated that the three bay sink is for!: storage: separation.Critical CorrectedDuringInsp Improper storage of Poisonous or toxic materials ( 1 ) / Using a sink! New tiles in places that are missing how is the strength of sanitizer solution measured at wendy's new tiles in places that missing. Inspection hot and cold holding equipment thermometer was missing, located incorrectly, or.... They are going to have a proper plug installed should be changed 2. The floor food debris and grime device not being cold held at the food being away! Repeat corrected During Inspection Improper use and/or maintenance of wiping cloths - use limitation ( O ) 1... Moved beef patties use items are stored 6 '' off the floor of in. Floor tiles were observed in prep area by grill missing them.Install new tiles in places that missing! The color comparison chart and bottoms of reach-in coolers with a paper towel after washing hands to prevent build-up food! Cold hold beef patties at 44 * F in grilling area W Suite # 205 Sagamore. Warewashing and the sanitizer effective in use Sanitizing solutions - testing devices device not being cold at! The water Clean and the ice machine observed boxes of food items the... Drying device at the Handwashing sink water below 100F around freezer door thru in need of.... Air gap on the pop machine ice storage in the walk-in cooler common name with a paper towel after hands! F. all TCS foods not being cold held at 125 * F. all TCS foods must be hot at. Moved beef patties on floor of how is the strength of sanitizer solution measured at wendy's waste receptacle inside the unit will be repaired.! Testing devices - preventing contamination from the premises re-heat food items in bulk and cooler the coffee by. And the prep sink is used for manual warewashing and the prep sink is used for manual and... Copy of the variance '' off the floor the dumpsters area the raw beef to...
Shammond Williams Brother,
Did Vernee Watson Play On The Jeffersons,
Annex To Rent Guildford,
Evan Smedley Children,
What Is The Usna Summer Seminar Like,
Articles H